features: compact 400w with 1u height power density: 11.11 watts/cu in 220w ~ 400w ac - dc active pfc switching power supply prl0602n single output series product specifications: input voltage: 90 ~ 264vac full range, 47 ~ 63hz. input current: 8a at 90vac full load. inrush current: max. 70a@230vac & 35a@115vac; both under cold start conditions. power factor correction: > 0.9 @ vin: 230vac full load. transient response: returns to within 1% in less than 2.5ms for a 50% load change and the peak transient does not excess 5%. overshoot: turn - on & off overshoot < 5% over nominal voltage. efficiency: 75minimum (measuring at 230v and full load). turn on delay : 1.5 second maximum at 120 vac. hold up time: 16ms min. at 75% of full load at 120vac. adjustability : output user adjustable +/ - 5% minimum. fan drive: 12vdc/300ma offering to drive an external fan. fan fail (ff) alarm: designated as ff on pin 3 of cn1, two types of logical signal provided, contact manufacturer. remote on - off: designated as inh on pin4 of cn1, requires a low signal to inhibit output. power supply on: green led designated as led1 on the pcb. power good: designated as pg on cn1 and ttl high 100 - 500ms after dc regulation. it goes low at least 1ms before loss of regulation. input fusing protection: one t8a/250v fuse inserted in primary. over - power protection: 110~140% of i - max; auto - recovery. short circuit protection: trip without damage and auto - recovery. over voltage protection: unit latching down when output exceed 130% and recycle ac input to reset. over - temperature protection: unit protected of excessive operating ambient 110 5 , and automatic recovery. operating temperature: 0 to 70 ambient, de - rating at 2.5% per degree from 50 to 70 . warranty: 2 years. switching frequency: 68khz pfc, 55 khz pwm vibration: 5 ~ 50 hz, acceleration 7.35 m/s*s on x,y and z axis. storage temperature : - 20 to 85 . operating humidity : 5% to 90% rh, non - condensing. storage humidity: 5% to 95% rh, non - condensing. emc: en55022 class b conducted / radiated, en61000 - 3 - 2, en61000 - 3 - 3; en55024 (iec61000 - 4 - 2, iec61000 - 4 - 3, iec61000 - 4 - 4, iec61000 - 4 - 5, iec61000 - 4 - 6, iec61000 - 4 - 11). safety regulation: ul1950, csa c22.2 no. 950 - 95, en60950 and cb certificate leakage current: < 3.5ma @ 264vac. (optional for 500ua max. at 240vac / 300ua max. at 120vac input) hi - pot test : 1500 vac input line to chassis (10ma ac cut off current); isolating 3000vac primary to secondary windings; primary to core 1500vac. all for 3 sec. grounding test: apply 25 a from ground pin of the three prong plug to the far most earth. max allowable resistance 0.1 ohm. warranty: 2 years. mtbf: 100000 hrs (according to mil - hbk - 217f) at 30 . cooling: internal fan is provided. enclosure : u type: 6(l) x 4(w) x 1.5(h) inches. c type: 6(l) x 4(w) x 1.57(h) inches. e type: 7(l) x 4(w) x 1.6(h) inches. f type: 6(l) x 4(w) x 2(h)inches. burn in: 45 +/ - 5 degree c for 1 hour @230vac with full load. weight : maximum weight is 800g. copy right ultra level tech co., ltd 2015, all right reserved. specifications subject to change without notice. e type: 7(l) x 4(w) x 1.6(h) f type: 6(l) x 4(w) x 2(h) c type: 6(l) x 4(w) x 1.57(h) u type: 6(l) x 4(w) x 1.5(h) cb ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465
output voltage / current rating chart: measured at output power connector. note: * prl0602n series are designated as prl0602nx - y where x can be u (u - chassis), c (u - chassis with top vented cover), e (enclosed type with end side built - in fan) or f (enclosed type with top cover built - in fan) or ,y can be 12, 15, 18, 24, 28, 36, 48 or 54 . ? prl0602nu series: u - chassis @400w max. with min. 26.84cfm forced airflow or 220w convection cooled output. ? prl0602nc series: u - chassis with vented cover@220w max. convection cooling. * prl0602ne series: enclosed with rear side built - in fan @400w max. * prl0602nf series: enclosed with top built - in fan @400w max. * all output ranges are covered in agency certifications and the preset voltage will be set as standard model if any request is not preset output please contact us in advance. * ripple and noise are measured from 10khz to 20mhz bandwidth at output with parallel 0.1f ceramic and 22f electrolytic cap aci tors. * providing peak power to 700w within 500us for all models, longer duty duration need contact manufacture. ? 1% minimum load is required to maintain the ripple and regulation. * output is fully isolated. input and output connector (cn2): terminal block - howder part no. hd - 121 - 7p or molex - mating jst vh series. input 5 pin connector (3 pin used, pin 2 & pin 4 removed), pcb labeling: l = line; n = neutral; g = chassis ground. output 10 pin connector. output pin assignment: (see table in right). mounting inserts: 6 places m4x0.7. maximum penetration 2mm. logic signal connector (cn1) : mating jst xhp - 4 or equivalent (chyao shiunn js - 2001 - 04); mating pins: jst sxh - 002t - p0.6 for awg 30 to 26. pin 1: pg, pin 2: rtn, pin3: ff, pin4: inh fan driver connector (fan1) : 12vdc/300ma is available to drive an external fan, mating connector jst p/n xhp - 2 (2 pins 0.98 pitch), equivalent (chyao shiunn js - 2001 - 02). howder molex pins 1 ~ 2: v+ pins 1 ~ 5: v+ pins 3 ~ 4: v - pins 6 ~ 10: v - pin 5: gnd pin 12: gnd pin 6: neutral pin 14: neutral pin 7: line pin 16: line outline drawing: copy right ultra level tech co., ltd 2015, all right reserved. specifications subject to change without notice. model output range preset voltage max. output current regulation ripple & noise type u & e & f (forced air) type u & c (convection) prl0602nx - 12 10 ~ 13.8v 12 v 33.33a 18.33a +/ - 1% 1% prl0602nx - 15 14 ~ 15.5v 15 v 26.67a 14.67a +/ - 1% 1% prl0602nx - 18 16 ~ 20v 18v 22.22a 12.22a +/ - 1% 1% prl0602nx - 24 21 ~ 26v 24v 16.67a 9.17a +/ - 1% 1% prl0602nx - 28 27 ~ 34v 28v 14.29a 7.86a +/ - 1% 1% prl0602nx - 36 35 ~ 42v 36v 11.11a 6.11a +/ - 1% 1% prl0602nx - 48 43 ~ 50v 48v 8.33a 4.58a +/ - 1% 1% prl0602nx - 54 51 ~ 60v 54v 7.41a 4.07a +/ - 1% 1% ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465
copy right ultra level tech co., ltd 2015, all right reserved. specifications subject to change without notice. prl0602nc series (u chassis with top vented cover): 6 (l) x 4(w) x 1.57(h) inches; weight: 650g. ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465 prl0602nu series (u - chassis type only): 6 (l) x 4(w) x 1.5(h) inches; weight: 600g.
ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465 copy right ultra level tech co., ltd 2015, all right reserved. specifications subject to change without notice. prl0602ne series (enclosed with rear side built - in fan type): 7 (l) x 4(w) x 1.6(h)inches; weight: 750g. prl0602nf series (enclosed with top built - in fan type): 6 (l) x 4(w) x 2(h)inches; weight: 800g.
|
